TOYOTA Avensis Wagon Intercooler coolant circuit repair Cost
2003–2006 · Engine, Fuel & Emissions system
Typical range
$293–$536
Parts + labour
Labour hours
1.5–5h
At a typical garage
The intercooler cools the compressed air from the turbocharger before it enters the engine, increasing air density and power. Leaks in the intercooler or its hoses reduce boost pressure and cause poor performance. TOYOTA Avensis Wagon intercooler service costs $293–$536.
Warning signs you need this repair
- Noticeable loss of power or sluggish acceleration under load
- Check engine light with underboost code P0299
- Black smoke from the exhaust when accelerating (oil contamination from the intercooler)
- Hissing sound from the engine bay under boost
- Poor fuel economy with reduced performance
What affects the price
- Hose or pipe replacement only vs full intercooler replacement
- Air-to-air vs water-to-air intercooler design
- Whether the boost pressure sensor or hose clamps also need attention
Common questions
How much does intercooler coolant circuit repair cost on a TOYOTA Avensis Wagon?
Intercooler coolant circuit repair on a TOYOTA Avensis Wagon (2003–2006) typically costs between $293 and $536 including parts and labour at an independent garage.
What parts are needed for intercooler coolant circuit repair on a TOYOTA Avensis Wagon?
Consult your mechanic for the specific parts required for your vehicle.
How long does intercooler coolant circuit repair take on a TOYOTA Avensis Wagon?
Intercooler coolant circuit repair on a TOYOTA Avensis Wagon typically takes 1.5–5 hours of labour at a garage.
How often does intercooler coolant circuit repair need to be done?
For a TOYOTA Avensis Wagon, intercooler coolant circuit repair is typically needed intercooler hoses should be inspected every 40,000–60,000 miles; intercooler replacement is on failure.
Other engine, fuel & emissions system repairs on the TOYOTA Avensis Wagon
- ABS hydraulic unit replacement$383–$701
- ABS sensor replacement$158–$289
- ABS system bleeding$126–$231
- AC compressor clutch replacement$315–$578
- AC compressor replacement$338–$619
Intercooler coolant circuit repair cost on similar cars
- VOLKSWAGEN Passat$293–$536
- OPEL Insignia$293–$536
- AUDI A4 Avant$293–$536
- FORD Mondeo Hatchback$293–$536
- RENAULT Laguna$293–$536
Get the exact price for your TOYOTA Avensis Wagon
Prices vary by year, engine and location. Tell us about your specific car.
Get my price estimate →